Engine
2.5L 4-cyl
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Fuel system
34 complaint records1 fire report
"VEHICLE WAS REPAIRED UNDER RECALL #94V106 IN OCT. OF 97. VEHICLE IS PRESENTLY LEAKING VAPOR. MANUFACTURER HAS BEEN NOTIFIED. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Engine & cooling
19 complaint records2 fire reports
"WHILE DRIVING 65 MPH THE VEHICLE WAS ENGULFED IN FLAMES. THE VEHICLE WAS TOTALLED. PLEASE PROVIDE ADDITIONAL INFORMATION.*JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Seat belts
14 complaint records1 crash report
"THE DRIVER'S SIDE SEAT BELT BUCKLE RED RELEASE BUTTON BROKE, CAUSING THE SEAT BELT NOT TO LATCH INTO THE BELT BUCKLE. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse seat belts parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA99014 opened Jun 1999 | closed Mar 2000 | Service Brakes, Hydraulic | BRAKE ROTER DISC/HUD SEPARATION - led to recall 99V340000 There is no summary currently available |
| RQ97016 opened Oct 1997 | closed Jun 1998 | Fuel System, Gasoline | FUEL LEAKAGE - led to recall 94V106000 ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS |
| PE95049 opened Aug 1995 | closed Jan 1996 | Suspension | REAR AXLE SHAFT SEPARATION THIS INVESTIGATION WAS OPENED TO EXAMINE THE FAILURE MODE AND THE RISK TO MOTOR VEHICLE SAFETY POSED BY ALLEGATIONS OF REAR AXLE SEPARATIONS.THE REAR AXLE SHAFT AND HOUSING DESIGN IS TYPICAL OF THOSE IN WHICH THE WEIGHT OF THE VEHICLE IS CARRIED ON THE AXLE... |
| EA93025 opened Oct 1993 | closed Nov 1994 | Power Train | DRIVESHAFT/UNIV.JOINT FAIL There is no summary currently available |
| PE93057 opened Jun 1993 | closed Oct 1993 | Power Train | DRIVESHAFT/UNIV.JOINT FAIL There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 02V041000 | Parking Brake | ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING. | Normally free |
| 94V106000 | Fuel System, Gasoline | VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS. | Normally free |
| 93V083000 | Electrical System | SALT CORROSION PRODUCTS BETWEEN THE STARTER SOLENOID WIRE AND THE ADJACENT BATTERY FEED IN THE BULKHEAD CONNECTOR MAY SHORT THESE CONNECTIONS, CAUSING THE CIRCUIT TO BYPASS THE IGNITION KEY CONTROL OF THE STARTER MOTOR... | Normally free |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| D-20-02 Rev. A Mar 2020 | Equipment | DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A) | |
| R2118796A Feb 2016 | Engine And Engine Cooling | Valve Body. These may cause over drive cycling. | |
| 9002849 Sep 2014 | Equipment | Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. | |
| 1802002 Jun 2002 | Unknown Or Other | FLASH PROGRAMMING FAILURE RECOVERY. *SLC | |
| 0800600REV Dec 2000 | Electrical System | SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB | |
| 080600 Feb 2000 | Electrical System | THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT | |
| 110798 Dec 1998 | Engine And Engine Cooling | OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE/BREAK. *AK | |
| 110798 Jul 1998 | Engine And Engine Cooling | THE OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE AND BREAK. *YC | |
| 081698 Apr 1998 | Equipment | INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK | |
| 070397 May 1997 | Engine And Engine Cooling | VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC | |
| 230397 Feb 1997 | Structure | DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW | |
| CH232695 May 1995 | Visibility | UNKNOWN | |
| CH231895 Apr 1995 | Structure | THE SPREADER BAR LOCATED BETWEEN THE CENTER AND REAR BOWS MAY NOT STAY IN THE LOCKED POSITION. *TW |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Pull and release every belt.A belt that retracts slowly or a buckle that will not latch matches this vehicle's seat-belt cluster.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Jeep Wrangler →