Engine
2.5L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Air bags
90 complaint records46 crash reports
"VEHICLE EXPERIENCED FAILURE OF THE RECALL REPAIR (99V-113) PRIOR TO RECALL NOTICE, WHICH CAUSED SHORT IN THE CIRCUIT. MJS..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse air bags parts in the directory →
Power train
69 complaint records3 crash reports
"WHILE DRIVING TRANSMISSION EXPLODED, MAKING A CLUCKING SOUND, AND THEN THE VEHICLE JUST STOPPED. DEALER HAS BEEN CONTACTED. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Engine & cooling
50 complaint records2 crash reports
"THE MANUAL SWITCH DOESN'T WORK FOR THE HEATER AND AIR CONDITION. THERE IS A OIL LEAKING FROM UNDERNEATH THE VEHICLE. NLM..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP96014 opened Nov 1996 | OPEN | Air Bags | DEFECTIVE AIR BAG CRASH SENSOR CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED... |
| DP03002 opened May 2003 | closed Jul 2003 | Steering | STEERING COLUMN SEPARATION MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED... |
| PE97049 opened Nov 1997 | closed Mar 1998 | Visibility | AIR BAG CIRCUIT/WINDSHIELD WIPER MOTOR There is no summary currently available |
| EA97003 opened Jan 1997 | closed Aug 1998 | Child Seat | INTEGRATED CHILD SEAT BELT LOCKUP - led to recall 98V185000 THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL. |
| SQ96016 opened Sep 1996 | closed Feb 1997 | Seat Belts | INTEGRATED CHILD SEAT BELT LOCKUP ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS... |
Show 1 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE96008 opened Jan 1996 | closed Jun 1996 | Seat Belts | SAFETY BLT LATCH OPERATION There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 99V113000 | Air Bags | VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1999104 1999-05-27 | Seats And Restraints | 129,978 | On certain vehicles, an intermittent short circuit in the air bag initiator wire that occurs between 1.5 to 1.7 seconds after vehicle start-up (or "key on") may lead to an inadvertent air bag deployment. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| R2118796A Feb 2016 | Engine And Engine Cooling | Valve Body. These may cause over drive cycling. | |
| 23-014-15 Apr 2015 | Equipment | Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. | |
| 1802002 Jun 2002 | Unknown Or Other | FLASH PROGRAMMING FAILURE RECOVERY. *SLC | |
| 0801001 May 2001 | Electrical System | SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT | |
| 0800600REV Dec 2000 | Electrical System | SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 2300800B Nov 2000 | Seats | SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT | |
| 082700 Sep 2000 | Air Bags | SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT | |
| 230800 Mar 2000 | Seats | SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT | |
| 080600 Feb 2000 | Electrical System | THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT | |
| 083799 Nov 1999 | Air Bags | DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT | |
| 233599REVA Oct 1999 | Structure | SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS | |
| 210599A Sep 1999 | Power Train | THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT | |
| 233599 Sep 1999 | Seats | INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT | |
| 220399 Apr 1999 | Tires | SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION. *TT | |
| 210699 Apr 1999 | Vehicle Speed Control | CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT | |
| 210599 Mar 1999 | Power Train | SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT | |
| 210499 Feb 1999 | Power Train | SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT | |
| 081798 Dec 1998 | Air Bags | SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC | |
| 070698 Nov 1998 | Engine And Engine Cooling | SOME SUBJECT VEHICLES MAY EXPERIENCE A LOOSENING OR LOSS OF THE NUT RETAINING THE ENGINE COOLING MODULE FAN CAUSING A VIBRATION INITIALLY. IF NOT ADDRESSED IMMEDIATELY, FAN BLADE WILL NOT TURN AND ENGINE COULD OVERHEAT. *AK | |
| 183298 Sep 1998 | Structure | SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC | |
| 081798 REV B Sep 1998 | Air Bags | SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC | |
| 9837 Aug 1998 | Air Bags | SUBJECT REGARDING A 30 DAY AIRBAG WIRING DIAGNOSTIC SURVEY. *AK | |
| 9837 Jun 1998 | Air Bags | INFORMATION ON 30 DAY AIRBAG WIRING DIAGNOSTIC SURVEY. *YC | |
| 210798 Apr 1998 | Power Train | SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK | |
| 081698 Apr 1998 | Equipment | INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK | |
| 090997 Dec 1997 | Engine And Engine Cooling | INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM | |
| 970919083297 Sep 1997 | Air Bags | AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC | |
| 0832097 Sep 1997 | Electrical System | INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM | |
| 241197 Jul 1997 | Equipment | CONCERNS WITH A/C EVAPORATOR ODOR. *NLM | |
| 220197 Jun 1997 | Tires | INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM | |
| 210997 May 1997 | Power Train | INFORMATION ON 41TE/42LE SERVICE INFORMATION. *NLM | |
| 070397 May 1997 | Engine And Engine Cooling | VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC | |
| 970314210597 Mar 1997 | Power Train | CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH) ENGAGEMENT, 3RD GEAR PARTIAL EMCC TO 4TH GEAR PARTIAL EMCC ENGAGEMENT, OR 4TH GEAR TO 4TH GEAR EMCC ENGAGEMENT. *YC | |
| 210597 Mar 1997 | Power Train | CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT. *NLM | |
| 180997 Feb 1997 | Power Train | VEHICLE SHUDDER DURING TORQUE CONVERTER EMCC (LOCK UP) OPERATION/DIAGNOSTIC TROUBLE CODE 38. *TW | |
| 230397 Feb 1997 | Structure | DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW | |
| 180597 Feb 1997 | Engine And Engine Cooling | VEHICLES WITH 3.0L ENGINES - INTAKE VALVE DEPOSITS - DRIVEWAY DIE OUT, ROUGH IDLE, LACK OF POWER, SAGS OR HESITATION. *TW | |
| 180197 Jan 1997 | Engine And Engine Cooling | ERRONEOUS MIL ILLUMINATION WITH HEX CODE $2E-EGR SYSTEM FAILURE. *JD | |
| 081695REVA Oct 1995 | Vehicle Speed Control | BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPERATION), THE VEHICLE MAY ACCELERATE AND... | |
| CH210695 Jun 1995 | Power Train | UNKNOWN | |
| CH240695A May 1995 | Equipment | UNKNOWN | |
| CH240895 May 1995 | Equipment | UNKNOWN | |
| CH081695 Apr 1995 | Vehicle Speed Control | CRUISE CONTROL OVERSHOOT/UNDERSHOOT DURING INITIAL SET SPEED SELECTION. *TW | |
| 180795A Mar 1995 | Power Train | HARSH TRANSAXLE SHIFTS. *T2W | |
| 110295 Mar 1995 | Engine And Engine Cooling | EXHAUST NOISE WHEN ACCELERATING OR WHEN VEHICLE IS UNDER MODERATE LOAD. *TW | |
| 180495A Feb 1995 | Power Train | START UP DIE OUT WITH NO FAULT CODES. *TW | |
| 180795 Feb 1995 | Power Train | HARSH TRANSAXLE SHIFTS. *TW | |
| 180495 Jan 1995 | Electrical System | START UP DIE OUT WITH NO FAULT CODES. *TW | |
| 070294A Dec 1994 | Engine And Engine Cooling | SERPENTINE BELT COMES OFF PULLEYS. *TW | |
| 182394 Dec 1994 | Engine And Engine Cooling | SAG OR HESITATION ON COLD START UP. *TW | |
| 182294 Dec 1994 | Vehicle Speed Control | HIGHER THAN NORMAL ACCELERATOR PEDAL EFFORT AT COLD START UP. *TW | |
| 052294 Dec 1994 | Service Brakes | ANTILOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED DUE TO WHEEL SPEED SENSOR CONNECTOR. *TW | |
| 240594A Dec 1994 | Visibility | LOW HEATER PERFORMANCE. *TW | |
| 080794B Dec 1994 | Power Train | HARSH SHIFTING AT LOW SPEED AND OR DIGITAL SPEEDOMETER FLUCTUATES. *TW | |
| 087594 Dec 1994 | Electrical System | INTERMITTENT GRINDING NOISE FROM STARTER. *TW | |
| 070394A Dec 1994 | Engine And Engine Cooling | SERPENTINE BELT COMES OFF PULLEYS. *TW | |
| 087794 Dec 1994 | Power Train | INOPERATIVE SPEEDOMETER. *TW | |
| 212694 Dec 1994 | Power Train | CLICKING NOISE FROM THE LEFT FRONT OF VEHICLE AT LOW SPEED. *TW | |
| 241794 Nov 1994 | Electrical System | PCM NOT PROPERLY DISENGAGING A/C CLUTCH VIA THE RELAY ALSO THE PCM MAY NOT ENERGIZE THE A/C CLUTCH RELAY. *TW | |
| 021994 Nov 1994 | Suspension | FRONT SUSPENSION - RAPPING NOISE WHEN TRAVELING OVER BUMPS. *TW |
Showing 60 of 62 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Watch the airbag warning light through a full key cycle.It should light on start and go out within seconds. A light that stays on, or never lights at all, means the system needs attention. Run the VIN for inflator recalls specifically.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Plymouth Voyager →