Engine
3.8L 6-cyl
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Glass & wipers
120 complaint records
"WINDOW ON RIGHT DRIVER SIDE AND ON LEFT REAR DRIVER SIDE BROKEN IN DOWN POSITION. NEITHER WINDOW WAS USED EXCESSIVELY. *JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse glass & wipers parts in the directory →
Body & structure
51 complaint records1 fire report
"THE DASH BOARD IS BUCKLING UP, WE ARE AFRAID IT MAY CAUSE THE AIR BAGS TO ACTIVATE CAUSING INJURY OR DEATH IF IT CAUSES AN WRECK. *KB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse body & structure parts in the directory →
Air bags
37 complaint records11 crash reports
"THE HORN REQUIRED EXCESSIVE PRESSURE TO ACTIVATE. THE DEALER STATED THE PROBLEM WAS DUE TO THE AIR BAG PLACEMENT. MR SCC *JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse air bags parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA02030 opened Oct 2002 | closed Mar 2004 | Fuel System, Gasoline | ENGINE COMPARTMENT FIRES - led to recall 04V090000 EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 02V222000 | Air Bags | CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT. | Normally free |
| 02V067000 | Steering | CERTAIN PASSENGER VEHICLES WERE BUILT WITH MISSING OR UNDER-TORQUED STEERING GEAR ATTACHMENT BOLTS. IF A BOLT IS MISSING, THE DRIVER MAY NOTICE UNEVEN STEERING RESPONSE OR UNUSUAL NOISES DURING TURNS. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2002151 2002-08-13 | Airbag | 14,654 | Certain vehicles may have a driver's side airbag inflator that could fracture at a weld during a deployment. Pieces of the inflator could strike and injure vehicle occupants and the airbag cushion would not inflate fully, reducing the... |
| 2002042 2002-03-08 | Steering | 5 | Certain passenger vehicles were built with missing or under-torqued steering gear attachment bolts. If a bolt is missing, the driver may notice uneven steering response or unusual noises during turns. |
| 2001272 2001-11-14 | Other | 11,337 | Certain vehicles have an improperly programmed vehicle theft deterrent system. Correction: dealers will reprogram the system. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIP5601C Jul 2025 | Unknown Or Other | This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC. | |
| 23-NA-001 Mar 2025 | Electrical System | This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information. | |
| PIP5358D Feb 2025 | Unknown Or Other | This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. | |
| PIP4723J Oct 2024 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIT5099H Sep 2024 | Unknown Or Other | This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. | |
| General Communication Aug 2024 | SERVICE CAMPAIGN | Electrical System | Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). |
| 24-NA-141 Jul 2024 | Power Train | GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. | |
| 16-NA-383 Jun 2024 | Engine | This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up. | |
| 18-NA-099 Jun 2024 | Unknown Or Other | This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim. | |
| 24-NA-098 Jun 2024 | Electrical System | This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information. | |
| 10-08-45-001H Mar 2024 | Electrical System | This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish. | |
| 16-NA-383 Mar 2024 | Engine And Engine Cooling | This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up. | |
| 22-NA-074 Feb 2024 | Engine And Engine Cooling | This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system. | |
| 18-NA-099 Jan 2024 | Equipment | This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim. | |
| 02-08-42-001J Jan 2024 | Exterior Lighting | This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage. | |
| PI1394B Jan 2024 | Power Train | This PI bulletin advises the technician on the proper way to install the pistons in an engine. | |
| PIP5601B Jan 2024 | Equipment | This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. | |
| 23-NA-219 Dec 2023 | Equipment | This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories. | |
| 17-NA-170 Oct 2023 | Wheels | This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement. | |
| 10-00-89-006J Sep 2023 | Equipment | This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only). | |
| PIT5099G Sep 2023 | Visibility | This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. | |
| 23-NA-153 Sep 2023 | Power Train | The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay. | |
| 18-NA-073 Aug 2023 | Engine And Engine Cooling | This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement. | |
| PIP5628G Aug 2023 | Engine | This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D | |
| PIP5358C Jul 2023 | Equipment | This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. | |
| 17-NA-170 Apr 2023 | Wheels | This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement. | |
| 19-NA-219 Apr 2023 | Engine And Engine Cooling | This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue. | |
| PIP5628F Apr 2023 | Engine And Engine Cooling | This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D | |
| 19-NA-219 Mar 2023 | Engine And Engine Cooling | This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue. | |
| 22-NA-009 Mar 2023 | Engine And Engine Cooling | This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters. |
Showing 30 of 385 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Run the wipers and washers, and test every window.Slow or stuck regulators, streaking wipers, and windshield cracks are this vehicle's visibility complaints.
- Walk the body slowly in daylight.Panel gaps, rust at the rockers and wheel arches, and cracked trim are this vehicle's structure complaints. Open and close the liftgate or trunk and look at the latch area.
- Watch the airbag warning light through a full key cycle.It should light on start and go out within seconds. A light that stays on, or never lights at all, means the system needs attention. Run the VIN for inflator recalls specifically.
- Run the VIN against open recalls before you negotiate.This vehicle has 2 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Buick Lesabre →